tiny hole in 6" duct pipe

Reply

  #1  
Old 07-20-19, 01:10 PM
Member
Thread Starter
Join Date: Mar 2019
Location: Canada
Posts: 64
tiny hole in 6" duct pipe

I was passing some co-axial cables through some existing holes drilled through my floor joists when I noticed a spot where two holes were drilled. On the other side of one of the holes is a 6" duct pipe and there is a tiny hole in it (approximately 1/32") I'm guessing from the drill bit used to drill the hole. When I put my finger to the hole I feel cold air coming out (AC is on). What is the best way to plug this hole? I'm sure the best way is to replace this section of pipe, but it looks like it would be a real pain in the a**.

The photo below doesn't show the hole. It just shows the duct pipe.
 
Attached Images  
Sponsored Links
  #2  
Old 07-20-19, 01:16 PM
XSleeper's Avatar
Group Moderator
Join Date: Dec 2004
Location: USA
Posts: 22,718
Upvotes Received: 127
Foil tape........................................
 
Shepweiler voted this post as helpful.
  #3  
Old 07-20-19, 03:29 PM
Member
Join Date: Dec 2005
Location: USA
Posts: 502
Upvotes Received: 9
Probably a mis-drilled screw hole, if you can get to it maybe screw a short sheet metal screw into it. And seal it with a little silicone sealer on the screw before installing it.
 
Shepweiler voted this post as helpful.
  #4  
Old 07-20-19, 03:43 PM
Member
Join Date: Oct 2008
Location: New England
Posts: 10,353
Upvotes Received: 16
Foil tape or duct mastic is often used to seal all junctions and seams in ducting, especially when those leak areas are outside the conditioned living space. If this area is conditioned then leakage is less important but sealing it does go in the right direction.

Looking closely at that picture is that a junction just above the orange wire and it doesn't look to be sealed. A roll of foil tape for the newly discovered hole could take care of some of the other seams and junctions.

Bud
 
Shepweiler voted this post as helpful.
Reply

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


Thread Tools
Search this Thread
Display Modes