Search: Posts Made By: JD305
Showing results 1 to 19 of 19
Search took 0.01 seconds.
09-04-17, 06:52 PM
Replies: 36
Views: 1,585
Posted By JD305

I'm going to remove the sensor from the edge of...

I'm going to remove the sensor from the edge of the pan ... maybe needs cleaning?

I understand the motherboard monitors it and it expecting a certain feedback .. somehow it's tripping .... since I...
09-04-17, 06:12 PM
Replies: 36
Views: 1,585
Posted By JD305

Primary pan looks white plastic

Primary pan looks white plastic
09-04-17, 04:21 PM
Replies: 36
Views: 1,585
Posted By JD305

:beers: thank you my friend ... no, I definitely...

:beers: thank you my friend ... no, I definitely understand the damage of an overflowing pan ... you only have to experience it once for it to never happen again!

I do have a digital meat...
09-04-17, 03:12 PM
Replies: 36
Views: 1,585
Posted By JD305

Ok ... I just did ... poured 2 full gallons from...

Ok ... I just did ... poured 2 full gallons from empty milk milk gallon ... water drains fine down into hose and out of the trap .. did not see any time where it looked like the pan was getting full.
09-04-17, 02:47 PM
Replies: 36
Views: 1,585
Posted By JD305

Thanks Houston! Ok .. So I have had both...

Thanks Houston!

Ok .. So I have had both panels off and have seen the panel dry when the lockout occurs ... just a dribble of water and down to the drain opening and out .. nothing ever...
09-04-17, 01:26 PM
Replies: 36
Views: 1,585
Posted By JD305

THANK YOU!!! Roughneck, Houston and PJ !!!!!

IT WORKED!!! .... keeping fingers crossed!

I disconnected the single wire to the Condensate Overflow Sensor ... and it's running like a champ!

How can such a simple part go bad???

The IN...
09-04-17, 11:49 AM
Replies: 36
Views: 1,585
Posted By JD305

So this is what I got putting into shorting into...

So this is what I got putting into shorting into TEST mode

6 flashes of the LED and 10 sec pause ... I'm assuming this stores the last fault registered?

Fault = "Condensate overflow"
Fault...
09-04-17, 08:34 AM
Replies: 36
Views: 1,585
Posted By JD305

I'm going to short the Test terminals and see...

I'm going to short the Test terminals and see what code comes out ... and look it up on the schematics chart

The IN/OUT water flow seems proper ... when the compressor kicks on the OUT flow Temp...
09-03-17, 08:27 PM
Replies: 36
Views: 1,585
Posted By JD305

Yes, it does .. you mean these pressure safety...

Yes, it does .. you mean these pressure safety switches? they are permanently attached though ... https://i.ytimg.com/vi/tj16Ec_utaA/maxresdefault.jpg
09-03-17, 07:10 PM
Replies: 36
Views: 1,585
Posted By JD305

When I brought the tech in for the initial...

When I brought the tech in for the initial assessment ... he checked the refrigerant pressures

however, I think this guy was not really experienced with these heat pump systems .... but the...
09-03-17, 07:06 PM
Replies: 36
Views: 1,585
Posted By JD305

located in Miami .. .it's 40 story condo building...

located in Miami .. .it's 40 story condo building about 700 units between the two buildings

It's a newer building, 2008

water temp coming in seems ambient .. like 94 degrees
09-03-17, 06:59 PM
Replies: 36
Views: 1,585
Posted By JD305

Circuit setter ... looks like this? ...

Circuit setter ... looks like this? http://s3.supplyhouse.com/images/products/zoom/117415lf-3.jpg
09-03-17, 06:41 PM
Replies: 36
Views: 1,585
Posted By JD305

Where could I find that strainer? .. I didn't see...

Where could I find that strainer? .. I didn't see it in any of the braided hoses when I disconnected them ... or maybe they just didn't put any in?
09-03-17, 06:30 PM
Replies: 36
Views: 1,585
Posted By JD305

I just reversed the cooling hoses from the...

I just reversed the cooling hoses from the building and flushed the IN hose into a bucket ... some dirty water can out, with some debris ... but nothing that would signal a clog in this circuit?
...
09-03-17, 04:47 PM
Replies: 36
Views: 1,585
Posted By JD305

In these Heat Pumps systems ... Isn't the...

In these Heat Pumps systems ... Isn't the condenser and the R22 plumbing circuit inside the compressor totally separate from the water coolant pipe loop that comes from the building? ... I should be...
09-03-17, 06:44 AM
Replies: 36
Views: 1,585
Posted By JD305

So I turned the breaker on this morning ... and...

So I turned the breaker on this morning ... and the system ran with the compressor for well over 5 minutes and cooled down to about 75 .. then compressor shut off

I touched the OUT flow pipe ......
09-02-17, 07:12 PM
Replies: 36
Views: 1,585
Posted By JD305

I put a Temp strip on the OUT pipe, just before...

I put a Temp strip on the OUT pipe, just before the braided line connects .. it gets a little warmer than the IN pipe when the compressor is running, but not 110 ... maybe 100/102 on the OUT with the...
09-02-17, 06:42 PM
Replies: 36
Views: 1,585
Posted By JD305

Thanks Pete! Yes, I did call the tech the...

Thanks Pete!

Yes, I did call the tech the second time (he didn't charge me) to come back and diagnose ... but after a week, I was back to the same problem.

Yes .. the cold coil I cleaned .....
09-02-17, 05:38 PM
Replies: 36
Views: 1,585
Posted By JD305

Climatemaster Heat Pump in South Florida Condo ...

Hello from South Florida!!! ... I've been troubleshooting my condo AC unit and have run into some questions hopefully you guys can drop some knowledge on me.

My Equipment = Climatemaster...
Showing results 1 to 19 of 19


 
Forum Jump